'Viking Star' - Roller Shutter Door

Specification:-

• 'Viking Star I' Self Coiling Operation.
• 'Viking Star II' Hand Chain Operation.
• 'Viking Star III' Electrical Operation (3ph or 1ph).
• 'Viking Star IV' Tubular Motor Operation.

Each shutter curtain is constructed from suitable interlocking galvanised steel laths and either a galvanised "T" section bottom rail or a heavy duty mild steel bottom rail, running in galvanised steel side channels, mounted on galvanised steel support angles which are bolted to the structure. The curtain weight is supported from a suitable steel tube barrel assembly at high level, running on quality steel bearings. The barrel assembly is supported between mild steel endplates and driven through gears. Self-coiling shutters are fitted with one pair of guide locks and chain operated shutter are fitted with chain keeps. All mild steel components are finished in one coat of primer.

Doors for openings above 4500mm wide are fitted with our tested wind anchor guide system as standard. Smaller sizes can be fitted with this system if required.

Operation:-

Manual operation is by means of a continuous galvanised haul chain, through single or double reduction gearing or self-coiling shutters by means of push up / pull down.

These doors are fitted with helically wound counter balance springs, fitted within the barrel assembly, to assist in operation. Each door is fitted with an anti fall-back safety device which prevents accidental dropping of the door curtain.

Electrical operation is by means of high quality single or three phase motor, gearbox and integral safety device incorporating six electrical limits. The safety device prevents accidental dropping of the door curtain. All controls are low voltage and have open, close and emergency stop buttons as standard. Emergency manual over ride is provided as standard to allow operation of the door in case of power failure.

Application:-

Each door is purpose-made to suit site dimensions and requirements and is suitable for all types of industrial use where insulation is not important.

Classifications:-

Under BS 13241-1, classifications are given to each door with regards to Wind Resistance, Water Resistance, Thermal Resistance and Air Permeability. Our standard classifications will be given at quotation stage or quotations can be given to meet individual classifications if required. A comprehensive log book is supplied with each door which will include operating instructions, maintenance instructions and all safety equipment details.

Optional Extras:-

• Plastisol coated laths.
• Galvanised steel coil casings.
• Rubber bottom seals.
• Wicket gates.
• Polyester powder coat finish.
• Special electrical automation and safety devices.

Send To A Friend

Print This Page

Contact Advanced Doors Limited

Request an 'Advanced Doors Limited Brochure'

Advanced Doors Limited, Park Mill Way, Clayton West, Huddersfield, West Yorkshire HD8 9XJ
Telephone: 01484 861112     Facsimile: 01484 861056     Email Advanced Doors Limited